CASE STUDIES
 
 

Power Factor Correction Unit Test

 
This is a notarized, at the load power factor correction unit test document showing the comparison of initial readings and optimized readings for a 400 HP Ammonia Screw Compressor at a large commercial cheese plant.		  

 

Centrex 40 HP Test

  
A 20 KVAR V-Blox PFC (Power Factor Correction) device was installed on a Toshiba 250 ton injection molding machine (40 horse powermotor) at Centrex. 		 

 

RCS Test Results

  
A Custom Built V-Blox PFC was specifically built for the subject equipment (Chiller) at Richmond Cold Storage - Chester Facility. 		 

 

Revere 50 HP Test

  
A 20 KVAR V-Blox PFC (Power Factor Correction) device was installed on a Toshiba 310 ton injection molding machine (50 horse power motor) at Revere. 		 

 

Power Factor Correction Unit Test

 
A 400-HP Air Blower was tested showing the KW electrical savings on the electrical circuit.		  

 

Rock Crushing Power Factor Test

  
The TEST not only yielded an actual KW savings, but also resulted in a substantial FUEL CONSUMPTION savings due to the reduced energy requirement by the CAT Diesel Generator.		  
 
 

KRAFT Foods Albany, MN

  The objective of this test was to measure and verify the applicable KW energy savings on a motor that is optimized with a custom engineered V-Blox Power Factor Correction Unit.
 
 
 

Master Electric Dranitz Test

   The test results clearly demonstrate a significant KW energy savings with an INCREASE in production. If we calculate out the increase in production so we are comparing "apples to apples", the resulting KW energy savings would be approximately 10% conservatively, and the KW required per pound of product produced would be reduced by approximately 13% conservatively.
 
 
 

City of Bloomington, MN PFC Unit Test

  The station pumped MORE gallons of water in 2006 using LESS energy with the PFC Unit installed.
 
 
 

Trudeau Distributing Power Factor Correction Test

  The objective of this test was to measure and verify the applicable Kilo-Watt (KW) energy savings on a Refrigeration Compressor Rack that is optimized with custom engineered V-Blox Power Factor Correction Units on each compressor.
 
 

 


 


Total Energy Concepts
1215 South Washington Ave.
Detroit Lakes, MN 56501
866.715.9569

Manufacturer: www.V-Blox.com

© Copyright 2008 Total Energy Concepts